Motorola MTP810 EX Service Manual

MTP810 ExBasic Service Manual

SAFETY INFORMATION ixRF Exposure Compliance and Control Guidelines and Operating InstructionsTo control your exposure and ensure compliance with the o

x SAFETY INFORMATIONApproved Accessories• Use only Motorola-approved supplied or replacement antennas, batteries, and accessories. Use of non–Motorola

SAFETY INFORMATION xiMedical DevicesPacemakersThe Advanced Medical Technology Association (AdvaMed) recommends that a minimum separation of 15 centime

xii SAFETY INFORMATIONUse of Communication Devices While DrivingAlways check the laws and regulations on the use of radios in the area where you drive

SAFETY INFORMATION xiiiIntrinsically Safe Radio InformationThe TETRA portable radios MTP850 Ex and MTP810 Ex are approved for use in potentially explo

xiv SAFETY INFORMATIONRepairA repair constitutes something done internally to the radio that would bring it back to its original condition. Items not

SAFETY INFORMATION xvDo Not Substitute Options or AccessoriesThe Motorola communications equipment certified as intrinsically safe by the approving ag

xviNotes

CONTENTS xviiCONTENTSCOPYRIGHT... iiDOCUMENT HISTORY.

xviii CONTENTSHow to Configure the IFR 3902 / IFR 2968 Setup ...

SCOPE & WARRANTY 1 - 1CHAPTER 1SCOPE & WARRANTYScope of this ManualThis manual is intended for use by service technicians familiar with simila

1 - 2 SCOPE & WARRANTYRelated Publications• 6866588D19 MTP850 Ex & MTP810 Ex Accessory Leaflet• 6866588D20 MTP850 Ex & MTP810 Ex Safety Bo

MODEL INFORMATION & ACCESSORIES 2 - 1CHAPTER 2MODEL INFORMATION & ACCESSORIESMTP810 Ex Model InformationThis manual applies to the following M

2 - 2 MODEL INFORMATION & ACCESSORIESMTP810 Ex Model SpecificationsSpecifications subject to change without notice.GENERAL RECEIVER TRANSMITTERETS

MODEL INFORMATION & ACCESSORIES 2 - 3Accessories Replacement Parts ListPlease refer to the MTP850 Ex & MTP810 Ex Accessory Leaflet(P/N: 686658

2 - 4 MODEL INFORMATION & ACCESSORIESAccessories NOT Allowed in a Potentially Explosive EnvironmentThe following accessories CANNOT be used in a p

MODEL INFORMATION & ACCESSORIES 2 - 5Others66007029001 RF RADIO REAR ANTENNA ADAPTOR66007029002 BATTERY ELIMINATORKit Number Description

2 - 6 MODEL INFORMATION & ACCESSORIESNotes

OVERVIEW 3 - 1CHAPTER 3OVERVIEWGeneralTo achieve a high spectrum efficiency, the MTP810 Ex uses digital modulation technology and sophisticated voice-

3 - 2 OVERVIEWVoice Compression TechnologyVoice is converted into a digital bit stream by sampling the voice at high rate and converting the samples i

ii COPYRIGHTCOPYRIGHTCopyrights© 2008 Motorola Inc. All rights reserved.No part of this manual may be reproduced, transmitted, stored in a retrieval s

OVERVIEW 3 - 3The transmitter path consists of a Cartesian Loop that contains the forward and feedback paths. The forward path includes the JAVELIN IC

3 - 4Notes

PROGRAMMING THE RADIO 4 - 1CHAPTER 4PROGRAMMING THE RADIONOTE: For programming the radio, refer to TETRA Customer Programming Software (CPS) User’s Gu

4 - 2Notes

TEST SETUP & TESTING 5 - 1CHAPTER 5TEST SETUP & TESTINGTypical Test SetupCarry out the following instructions before testing:• Check that you

5 - 2 TEST SETUP & TESTINGConnect the red (+) and black (-) wires of the battery eliminator to the respective positive and negative points of the

TEST SETUP & TESTING 5 - 3Transmitter Tests1. Power Burst (Control Range)2. Power Profiles3. Tx Burst Timing Error4. Vector Error RMS and Peak5. T

5 - 4 TEST SETUP & TESTINGCall Processing Tests1. Talk Back2. Call to MobileDuplex TestDigital Duplex Test (Tx)Measurement Capabilities: Bar chart

TEST SETUP & TESTING 5 - 5Power On Registration: RequiredPower Off De-registration: RequiredPriority Cell: YesMinimum Mode Service: May Be UsedMig

5 - 6 TEST SETUP & TESTINGFor IFR 2968, perform the following steps to configure the unit with the radio set:1. Turn ON the IFR.2. Press “Systems”

DOCUMENT HISTORY iiiDOCUMENT HISTORYThe following major changes have been implemented in this manual since the previous edition:Edition Description Da

TEST SETUP & TESTING 5 - 7System Wide Services: normal mode18. Press “More” soft key.TETRA Voice Service: supportedCircuit Mode Data Service: supp

5 - 8 TEST SETUP & TESTINGHow to Configure the IFR 3902 / IFR 2968 Manual Test ScreenFor IFR 3902, perform the following steps to configure the ma

TEST SETUP & TESTING 5 - 9RF Tests using IFR 3902 / IFR 2968Receiver TestsNote: This test requires programming the radio. Refer to TETRA Customer

5 - 10 TEST SETUP & TESTINGTransmitter TestsFor IFR 3902, perform the following steps:1. Press “TAB” soft key to select RF Settings.2. Enter “-90”

TEST SETUP & TESTING 5 - 11Call Processing Tests using IFR 3902 / IFR 2968Talk BackBefore you start this test, make sure that handset and test equ

5 - 12 TEST SETUP & TESTINGDigital Duplex Test (Tx) using IFR 3902 / IFR 2968For IFR 3902, perform the following steps:1. Go to "Menu" o

TEST SETUP & TESTING 5 - 13For IFR 2968, perform the following steps:1. Go to "Menu" of the radio, then select "Contact".After

5 - 14 TEST SETUP & TESTINGManual Mode TestingPreparation for Testing1. Verify that the radio is turned off.2. Press the “Left” and “Mute” keys to

TEST SETUP & TESTING 5 - 1512. Press any key again. The display shows"Connect accessory:1. RSM2. SB96003. RS232 Cable4. Light Headset5. Heavy

5 - 16 TEST SETUP & TESTING22. Press and key .The display shows EmergencyLeft Menu RightSend endUp PttDown Mut

ivNotes

TEST SETUP & TESTING 5 - 17Charger Recognition Test• Turn the radio ON.• Connect the handset to the Desktop Charger. Check whether the LCD display

5 - 18Notes

MAINTENANCE 6 - 1CHAPTER 6MAINTENANCEPreventive MaintenanceInspection and CleaningCheck that the external surfaces of the radio are clean, and that al

6 - 2Notes

SERVICE INFORMATION A - 1APPENDIX ASERVICE INFORMATIONServicing MTP810 Ex Portable RadiosService for the radios is based on the substitution method; a

A - 2 SERVICE INFORMATIONEMEA Systems Support Centre (ESSC)The Systems Support Centre is available at:Piece PartsSome replacement parts, spare parts,

SERVICE INFORMATION A - 3Recommended Programming EquipmentService Replacement Kit MatrixNote: All models listed in the Service Tanapa Column are not f

A - 4Notes

© 2008 by Motorola Inc. All rights reserved.Motorola Technology Sdn Bhd (Co. No. 455657-H)Plot 2 Bayan Lepas Technoplex Industrial ParkMukim 12 S.W.D1

Technical Information UpdatesAs we continue to make engineering enhancements to our products, the information in our Service Manuals need to be update

Service Manual Feedback FormWe believe that reports from users provide valuable information for producing quality manuals. Kindly take a few moments t

SAFETY INFORMATION viiSAFETY INFORMATIONProduct Safety and RF Exposure for Portable Two-Way RadiosRF Energy Exposure Awareness and Control Information

viii SAFETY INFORMATIONFederal Communication Commission (FCC) Regulations (US markets only)The FCC rules require manufacturers to comply with the FCC